|
|
|
|
|
#1
02-13-2006, 01:39 PM
|
|||
|
|||
|
300D Minor Starting Problem
Hi All, Had a little trouble getting my car running this morning. Temp was around 15F, not usually a problem for this car. I turned the key, the glow light went on but off again real quick. I re-cycled a few times and eventually the light stayed on for the expected 10 seconds or so. The car started but with a fair amount of cranking. Valves are good, GP's are new last spring fuel is fresh and has PS dumped into it.
The way the lamp was working almost seemed like an ignition switch problem as if wiggling the key, fooling around off and on would get the GP system to come on properly. Would a flaked out relay act like this? The relay looks to be about the easiest thing to work on that I've seen with this car. Is the part expensive (100+) and would you recommend swapping this out first before replacing the ign switch? Do the relays fail over time? Car is a 1983 and has 202K. Thanks much.
__________________
1985 300D 197K - Semi-Daily Driver Diesel 1998 Volvo V70 AWD 226K - Daily Driver 2 1998 Volvo S70 140K - Wife's DD 2003 GMC Sonoma ZR2 Option - Rusty Truck THE BABY 1958 220S Sedan 66K All original, never restored and never will be. 
|
|
#2
02-13-2006, 01:43 PM
|
||||
|
||||
|
it sounds like
the gps are not working to me.
i would check the fuse strip first. tom w
__________________
[SIGPIC] Diesel loving autocrossing grandpa Architect. 08 Dodge 3/4 ton with Cummins & six speed; I have had about 35 benzes. I have a 39 Studebaker Coupe Express pickup in which I have had installed a 617 turbo and a five speed manual.  [SIGPIC]..I also have a 427 Cobra replica with an aluminum chassis.
|
|
#3
02-13-2006, 02:19 PM
|
|||
|
|||
|
Do you mean the main fuse setup under the hood near the driver side firewall? This afternoon I turned on the key, the glow light came on and the car started with less than a full crank. It's about 25F or so but I think starting that quickly must mean the gps fired up this time. I did do a full fuse replacement on the car when I got it, about two years ago. I'll plug the car in tonight which always lets it start right away. I'm going to run a gp test too. Do they glow red when operating?
Thanks.
__________________
1985 300D 197K - Semi-Daily Driver Diesel 1998 Volvo V70 AWD 226K - Daily Driver 2 1998 Volvo S70 140K - Wife's DD 2003 GMC Sonoma ZR2 Option - Rusty Truck THE BABY 1958 220S Sedan 66K All original, never restored and never will be.
|
|
#4
02-13-2006, 02:34 PM
|
|||
|
|||
|
Starting
1984 300d Turbo
Pemove The 5 Pin Plug In Glow Plug Relay Box And Check Each Glow Plug Pin To Engine Ground 1 Ohm Or Less And Clean The Glow Holes With A Reamer Tool From ************************ $50.00, Carbon Is Overheating The Glow Plugs And They Burn Out They Will Read Open No Heat I Found 4 Open, Autozone Have In Stock, Check On Line
|
|
#5
02-13-2006, 04:55 PM
|
|||
|
|||
|
Ok, I'll try that. I did ream out when I changed the gps in the spring. Can the relay be cleaned? or is it just as well to replace it. The ohm check will be first as I have heard of gps being bad out of the box.
Thanks
__________________
1985 300D 197K - Semi-Daily Driver Diesel 1998 Volvo V70 AWD 226K - Daily Driver 2 1998 Volvo S70 140K - Wife's DD 2003 GMC Sonoma ZR2 Option - Rusty Truck THE BABY 1958 220S Sedan 66K All original, never restored and never will be.
|
 |
| Bookmarks |
|
|
Linear Mode
