Parts Catalog Accessories Catalog How To Articles Tech Forums
Call Pelican Parts at 888-280-7799
Shopping Cart Cart | Project List | Order Status | Help



Go Back   PeachParts Mercedes-Benz Forum > Mercedes-Benz Tech Information and Support > Diesel Discussion

Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 05-04-2003, 12:22 PM
jassz's Avatar
Registered User
 
Join Date: Feb 2003
Location: British Columbia, Canada
Posts: 402
Question Sunroof seal replacement

We just spent $700 in rust repairs to make the cabin dry. The passenger side is now dry, but the driver's side still has water. I began to suspect it was coming from the roof rather than the floor (even though the ceiling looked fine... they must have designed it so everythign travels down the wall). With a watering can I was able to determine that the rubber seal on the sunroof has come loose in one spot. I can find the part on-line here, but the service manual doesn't cover replacing it. Is it just a matter of taking off the old and putting in the new? Any secret handshakes you have to know?

Oddly enough, there is now water accumulating in the floor of the back seat too (driver's side) which I had not noticed before. I'm hoping it's the same source. On the upside, I don't have to remember to pack water for the dogs.

Sigh, did I mention it rains every damn day here?

__________________
Natalie

Last edited by jassz; 05-04-2003 at 01:34 PM.
Reply With Quote
  #2  
Old 05-04-2003, 01:41 PM
Moderator
 
Join Date: Jul 2001
Location: Woolwich, Maine
Posts: 3,598
jassz,

This is a chronic problem and the most frequent culprit is a clogged body or sunroof drain. These are located at the hood hinge mechanism under the hood, and usually fill up with tree "droppings" like leaves and pine needles, pollen pods and so on. The sunroof drains are located in the "A" pillars and the "C" pillars on sedans, not sure on a wagon. They can be blown out with compressed air.

In reality the rubber and felt seals really serve to make wind noise low enough not to bother you at speed and merely limit leakage to something less than the drainage features can handle. The metal roof hole is larger in all dimensions than the hole on inner roof and interior liner. There are small gutter like features (cofferdam?) around the outside edge of the inner hole to lead drainage/leakage away from the path to the interior and out to these drains. Technically they should be able to handle the job with no seals in place, although parking on a hill or tipped to one side might overwhelm them since only one or two would be called into service.

When they get clogged with junk, also usually tree droppings, they make the water find another path, which often means the water passes through the car's interior.

There are also cases reported where the windshield and rear window seals fail, crack, or break off in chunks and let water into the areas where it was never intended. Once again, the path to the lowest potential energy can pass through the car's interior.

This is a repeat problem brought up on the site and you should be able to do a search and find lots of discussion. Good luck, Jim
__________________
Own:
1986 Euro 190E 2.3-16 (291,000 miles),
1998 E300D TurboDiesel, 231,000 miles -purchased with 45,000,
1988 300E 5-speed 252,000 miles,
1983 240D 4-speed, purchased w/136,000, now with 222,000 miles.
2009 ML320CDI Bluetec, 89,000 miles

Owned:
1971 220D (250,000 miles plus, sold to father-in-law),
1975 240D (245,000 miles - died of body rot),
1991 350SD (176,560 miles, weakest Benz I have owned),
1999 C230 Sport (45,400 miles),
1982 240D (321,000 miles, put to sleep)
Reply With Quote
  #3  
Old 05-04-2003, 01:48 PM
jassz's Avatar
Registered User
 
Join Date: Feb 2003
Location: British Columbia, Canada
Posts: 402
Jim, thanks for the advise. But just to clarify, are you saying that the rubber seal being unattached for about 4 inches would not be causing the leak? That the drainage system in the car should be able to handle it (if it werent' clogged)?

I used a watering can with a narrow spout so that I could control the direction of water. When I hit one area it poured in through the ceiling. Upon inspection, I could see that the rubber seal wasn't attached in that area. But, this experiment is different than what happens in 'real life'. The water does not come through the ceiling, and obviously it rains all over :p .

Anyway, thanks for the tip! I'm off to look for the drains!
__________________
Natalie
Reply With Quote
  #4  
Old 05-04-2003, 02:15 PM
Moderator
 
Join Date: Jul 2001
Location: Woolwich, Maine
Posts: 3,598
jassz,

If by not being attached the rubber seal is hanging over the interior openning and directing water to the wrong side of the cofferdam, then it should be put back in place or removed. And yes, the drains should be able to keep up with a chunk of missing "seal" material, unless you are parked on a significant tilt. Good luck, Jim
__________________
Own:
1986 Euro 190E 2.3-16 (291,000 miles),
1998 E300D TurboDiesel, 231,000 miles -purchased with 45,000,
1988 300E 5-speed 252,000 miles,
1983 240D 4-speed, purchased w/136,000, now with 222,000 miles.
2009 ML320CDI Bluetec, 89,000 miles

Owned:
1971 220D (250,000 miles plus, sold to father-in-law),
1975 240D (245,000 miles - died of body rot),
1991 350SD (176,560 miles, weakest Benz I have owned),
1999 C230 Sport (45,400 miles),
1982 240D (321,000 miles, put to sleep)
Reply With Quote
  #5  
Old 05-04-2003, 09:32 PM
jassz's Avatar
Registered User
 
Join Date: Feb 2003
Location: British Columbia, Canada
Posts: 402
Well, upon inspection we discovered that the Rust Repair Guy PLUGGED the drains with silicone! No wonder it was worse after he fixed it. I am not very happy with the work the guy did overall, but do I keep going back when I'm starting to doubt his abilities??

__________________
Natalie
Reply With Quote
Reply

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On
Trackbacks are On
Pingbacks are On
Refbacks are On




All times are GMT -4. The time now is 02:52 PM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
Search Engine Optimization by vBSEO 3.6.0
Copyright 2024 Pelican Parts, LLC - Posts may be archived for display on the Peach Parts or Pelican Parts Website -    DMCA Registered Agent Contact Page