|
|
|
|
|
#1
08-15-2010, 06:46 PM
|
|||
|
|||
|
5 HP Briggs engine problem, carb?
Have a rototiller with this engine:
http://www.briggsandstratton.com/maint_repair/manual_and_more/docmanualdetails.aspx?showpdf=MS6817_LO.pdf Carb is on page 5 and is a 697028. I drained the old gas and put in fresh. I cleaned the carb, dropped bowl, sprayed gumout through everything. It will run fine as long as you spray starter spray into it. So I assume that means the spark is OK. Gas runs out of hose when valve/petcock opened. Bowl has gas in it. Is this definitely a carb problem? New one is 50.00. Any ideas? Thanks
__________________
1998 C230 330,000 miles (currently dead of second failed EIS, yours will fail too, turning you into the dealer's personal human cash machine) 1988 F150 144,000 miles (leaks all the colors of the rainbow) Previous stars: 1981 Brava 210,000 miles, 1978 128 150,000 miles, 1977 B200 Van 175,000 miles, 1972 Vega (great, if rusty, car), 1972 Celica, 1986.5 Supra 
|
|
#2
08-15-2010, 06:50 PM
|
||||
|
||||
|
Quote:
I would change the spark plug and air filter before a new carb, youll need them either way
__________________
 1982 300CD Turbo (Otis, "ups & downs") parts for sale 2003 TJ with Hemi (to go anywhere, quickly) sold 2001 Excursion Powerstroke (to go dependably) 1970 Mustang 428SCJ (to go fast) 1962 Corvette LS1 (to go in style) 2001 Schwinn Grape Krate 10spd (if all else fails)
|
|
#3
08-15-2010, 06:54 PM
|
|||
|
|||
|
Pull the jet out and clean it. It's plugged up. No need for a new carb.
__________________
1977 300d 70k--sold 08 1985 300TD 185k+ 1984 307d 126k--sold 8/03 1985 409d 65k--sold 06 1984 300SD 315k--daughter's car 1979 300SD 122k--sold 2/11 1999 Fuso FG Expedition Camper 1993 GMC Sierra 6.5 TD 4x4 1982 Bluebird Wanderlodge CAT 3208--Sold 2/13
|
|
#4
08-15-2010, 06:55 PM
|
||||
|
||||
|
Quote:
__________________
TC Current stable: - 2004 Mazda RALLYWANKEL - 2007 Saturn sky redline - 2004 Explorer...under surgery. Past: 135i, GTI, 300E, 300SD, 300SD, Stealth
|
|
#5
08-15-2010, 08:07 PM
|
|||
|
|||
|
The part they label as the jet is the screw/plug that holds the bowl on. It is as clean as a whistle. I sprayed all the little passages I think.
__________________
1998 C230 330,000 miles (currently dead of second failed EIS, yours will fail too, turning you into the dealer's personal human cash machine) 1988 F150 144,000 miles (leaks all the colors of the rainbow) Previous stars: 1981 Brava 210,000 miles, 1978 128 150,000 miles, 1977 B200 Van 175,000 miles, 1972 Vega (great, if rusty, car), 1972 Celica, 1986.5 Supra
|
|
#6
08-15-2010, 08:17 PM
|
||||
|
||||
|
Take the carb off and spray it with carb cleaner, also double check that all 3 holes in the Jet bolt are completely clear, also check that your float, Needle and seat move properly
__________________
hum..... 1987 300TD 311,000M Stolen. Presumed destroyed
|
|
#7
08-15-2010, 08:29 PM
|
|||
|
|||
|
Float and needle move good. As I recall there were two holes in the middle where the jet/plug screws in and at least one more in another location. The two in the middle, one was bigger than the other. I feel like I had them cleared but not sure. So you all think this is definitely a carb symptom? Is there some definitive test to make sure they are all clear. This is an Intek engine.
__________________
1998 C230 330,000 miles (currently dead of second failed EIS, yours will fail too, turning you into the dealer's personal human cash machine) 1988 F150 144,000 miles (leaks all the colors of the rainbow) Previous stars: 1981 Brava 210,000 miles, 1978 128 150,000 miles, 1977 B200 Van 175,000 miles, 1972 Vega (great, if rusty, car), 1972 Celica, 1986.5 Supra
|
|
#8
08-15-2010, 08:35 PM
|
|||
|
|||
|
Part number 633 is the jet I think. Did you take it out and clean it?
__________________
1977 300d 70k--sold 08 1985 300TD 185k+ 1984 307d 126k--sold 8/03 1985 409d 65k--sold 06 1984 300SD 315k--daughter's car 1979 300SD 122k--sold 2/11 1999 Fuso FG Expedition Camper 1993 GMC Sierra 6.5 TD 4x4 1982 Bluebird Wanderlodge CAT 3208--Sold 2/13
|
|
#9
08-15-2010, 08:56 PM
|
|||
|
|||
|
The jet is 117. 633 is a foam shaft seal. 117 is very clean. Pretty big holes in that one.
__________________
1998 C230 330,000 miles (currently dead of second failed EIS, yours will fail too, turning you into the dealer's personal human cash machine) 1988 F150 144,000 miles (leaks all the colors of the rainbow) Previous stars: 1981 Brava 210,000 miles, 1978 128 150,000 miles, 1977 B200 Van 175,000 miles, 1972 Vega (great, if rusty, car), 1972 Celica, 1986.5 Supra
|
 |
| Bookmarks |
|
|
Linear Mode
