Parts Catalog Accessories Catalog How To Articles Tech Forums
Call Pelican Parts at 888-280-7799
Shopping Cart Cart | Project List | Order Status | Help



Go Back   PeachParts Mercedes-Benz Forum > Mercedes-Benz Tech Information and Support > Tech Help

Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 01-24-2001, 06:49 PM
Crowe's Avatar
Benz Enthusiast
 
Join Date: Apr 2000
Location: Atlanta, GA
Posts: 366
I have reviewed my 300E owner's manual and can not find any discussion on checking the power steering fluid (oil) level. The first thing in the morning I have noticed a sound when turning out of the drive. The sound is like I have experienced with American cars in the past when the fluid level is low. Checking the brochure of factory approved service products the only source of power steering oil appears to be the dealer. Does MBZ use a different fluid/oil than other cars? Is the can at the front of the engine with the black plastic knob in the center of the top for the power steering oil? Any suggestions about the procedure to check the power steering fluid level?

__________________
  • 2001 E320
Reply With Quote
  #2  
Old 01-24-2001, 07:49 PM
MikeTangas's Avatar
Senior Member
 
Join Date: Apr 2000
Location: So. Cal
Posts: 4,430
That sounds like the power steering resevoir. Should look about the size of a small coffee can. Unscrew the knob and lift off the top. There is a line stamped in the body, about 1/2 inch below the rim, that's the fill line, the filter should be under the plate with holes in it at the bottom. Any quality power steering fluid will work.
__________________
Mike Tangas
'73 280SEL 4.5 (9/72)- RIP
Only 8,173 units built from 5/71 thru 11/72

'02 CLK320 Cabriolet - wifey's mid-life crisis

2012 VW Jetta Sportwagon TDI...at least its a diesel

Non illegitemae carborundum.
Reply With Quote
  #3  
Old 01-24-2001, 09:13 PM
Registered User
 
Join Date: Jun 1999
Location: Surrey, Beautiful British Columbia, Canada
Posts: 750
though expensive, i'd recommend MB fluid.
Reply With Quote
  #4  
Old 01-24-2001, 09:46 PM
Mr. BILL's Avatar
Ghoulardi Rules!
 
Join Date: Aug 2000
Location: Austin, TX
Posts: 576
My '90 300SE groans a little when I turn right for about a second. I looked at the fill reservoir and it was about 1/2" from the top. I put a little more in, but it still groans.

Does this sound like a pump going bad?
__________________
Mr. BILL

91 300E 120K
90 300SE 275K (sold)
92 BMW 525iM 120K
90 BMW 525iA 175K
85 300D 175K (sold)
84 300SD 245K (sold)
Reply With Quote
  #5  
Old 01-24-2001, 10:27 PM
dlswnfrd
Guest
 
Posts: n/a
Crowe

You found it alright, that little black knob. And the M/B suggested products only list M/B Fluid. My '87 W124030 has 170,600 miles and has had no steering gear or pump problems. A little trick I use is as I change my oil from the Top Side with my El Cheapo Oil pump, I remove the P/S pump oil filter and using my pump I suck the resevior empty and refill it with Valvoline Synthetic P/S fluid. I do this ever 3500-4000 miles. I also do something similar to the transmission. Overkill? Oils Cheap, Pumps and Gears ain't. As for noise, the power steering pump at end lock can produce up to 1000psi, noise will be heard. This is for the cirulating nut steering gear, not Rack & pinion which is another topic for discussion.

Happy Trails Beep Beep from Houston.

Donald
AJ likes Vavaleen
Reply With Quote
  #6  
Old 01-26-2001, 06:09 PM
Crowe's Avatar
Benz Enthusiast
 
Join Date: Apr 2000
Location: Atlanta, GA
Posts: 366
Just checked the power steering fluid level and found that it was at the top of the plate above the P/S filter. That leaves approximately 3-4 inches up to the top of resevoir empty. I did not see a fill line on the resevoir, but expect that the fluid/oil level has got to be higher. Someone mentioned that the fill level would be up to 1/2 inch of the top. Is that level correct?

I am attending a MBCA Peachtree Section meeting at a local MBZ dealer in the morning, so I will purchase some MB power steering oil and take care of the problem.
__________________
  • 2001 E320
Reply With Quote
  #7  
Old 01-26-2001, 11:00 PM
dlswnfrd
Guest
 
Posts: n/a
Crowe

You're doing the right thing in attending those training sessions. For then you will get it like it is, not he said or I heard not I do and and he doesn't . I wish you well and hope you get more involved with your machine for that's where the joy is, mono e mono, one to one.
Happy Trails Beep Beep from here to help Houston.
Donald
Reply With Quote
  #8  
Old 01-27-2001, 01:40 AM
MikeTangas's Avatar
Senior Member
 
Join Date: Apr 2000
Location: So. Cal
Posts: 4,430
Crowe,

Your fluid is big time low. Once you start up, it'll drop even lower as the fluid starts moving. I say it will drop lower, because as low as it is, you've likely got air in the system. Best part is, it will self bleed, just give it time. Fill it up, and let it idle for a while, then slowly turn the wheel stop to stop, afterwards check level again and top off.

Next, for the level to get that low, you probably have a leak in the system. Notice any oily puddles on the garage floor lately? Could be a leak in the hoses, front seal of the pump or from the steering box, or it's just never been checked. Until you verify you do or do not have a leak, I would check every other day to gauge usage, and top off as necessary.

__________________
Mike Tangas
'73 280SEL 4.5 (9/72)- RIP
Only 8,173 units built from 5/71 thru 11/72

'02 CLK320 Cabriolet - wifey's mid-life crisis

2012 VW Jetta Sportwagon TDI...at least its a diesel

Non illegitemae carborundum.
Reply With Quote
  #9  
Old 01-27-2001, 07:42 AM
2.5 TURBO
 
Join Date: Jan 2001
Location: Send me back to Atlanta
Posts: 876
Power steering pump

I use the Slick 50 Power Steering fluid, I had Mazda van that the Power Steering Pump squealed all the time, instead of changing it out I replaced the fluid with Slick 50 and it Stopped. Saved about $200
__________________
2000 Ford 7.3 Powerstroke 4x4
2006 Mazda Tribute
1983 Black 300 D (donated to charity)
1993 Teal 300 D (160K) Sold
"I love the smell of burnt diesel fuel in the morning, it smells like ....VICTORY"

Semper Fidelis
USMC 1973-1976
Reply With Quote
  #10  
Old 01-27-2001, 09:14 AM
Crowe's Avatar
Benz Enthusiast
 
Join Date: Apr 2000
Location: Atlanta, GA
Posts: 366
Thanks everyone!

I did notice some oil on the garage floor following the last oil change. I have always had a few drops on the floor but this was more than usual. I think that the person at the shop must have checked the power steering reservoir and did not retighten the lid properly. What I thought was oil must have been P/S oil/fluid. The side of the reservoir looked like it had a oil stain down the side, and the puddle on the floor was on that side of the engine. By the way, I was surprised to see that the "fluid" was black, not clear or red like other standard P/S fluid. Is this just unique to Mercedes?
__________________
  • 2001 E320
Reply With Quote
  #11  
Old 01-27-2001, 09:27 AM
BlackE55
Guest
 
Posts: n/a
Crowe,

I have a small p/s leak -- likely a high pressure hose and the "drips" are clear. I just topped of the resevior with MB fluid.

Shouldn't be black unless it's mixing with oil or grime before it hits the floor. Perhaps cleaning up the engine and re-checking will narrow down the culprit.

Best,
Reply With Quote
  #12  
Old 01-27-2001, 10:39 AM
Registered User
 
Join Date: Nov 2000
Location: Vernon, CT
Posts: 1,848
Did MB change their pumps? For my W116 the manual says use ATF. For my '99 VW, the manual says use a special mineral hydraulic oil. When I bought my W116 in October I checked all the fluids and the fluid that was in the steering pump was not red like ATF, it was more of a gold color. The pump doesn't leak, nor is there any steering pump noise. Just as a percaution should I some how flush out the system and put in ATF?
__________________
1999 MB SL500 (110,000 mi)
2004 Volvo V70 2.5T (220,000 mi)
2014 Tesla Model S 85 (136,000 mi)
MBCA member
Reply With Quote
  #13  
Old 01-27-2001, 12:47 PM
BlackE55
Guest
 
Posts: n/a
Slight correction on color

I should say the P/S fluid (for W126) is not clear per se, but yes, a more yellowish color. It does not look like oil, nor is it as red as say Dextron III.
Reply With Quote
  #14  
Old 01-27-2001, 03:43 PM
Crowe's Avatar
Benz Enthusiast
 
Join Date: Apr 2000
Location: Atlanta, GA
Posts: 366
Power Steering Oil/Steering Gear Lubricant

Just got back from the MBZ Dealer and purchased a quart of Mercedes-Benz P/S oil. It is a yellow-gold color and quite expensive. In fact, the parts guy suggested that I might want to use Dextron III. I will keep an eye on the oil level to make sure there is not a leak.
__________________
  • 2001 E320
Reply With Quote
  #15  
Old 01-27-2001, 03:59 PM
MikeTangas's Avatar
Senior Member
 
Join Date: Apr 2000
Location: So. Cal
Posts: 4,430
Even though on many models you can use ATF in the steering, I still use steering fluid. It may cost a little more but there have been suggestions that the detergents etc in current ATF composition can harm the pump and/or steering box seals. Plus as an added benefit, when you have drips on the deck, it's easier to tell at a glance what is leaking. If your fluid had gotten black, you definitely need to change your steering fluid and filter.

__________________
Mike Tangas
'73 280SEL 4.5 (9/72)- RIP
Only 8,173 units built from 5/71 thru 11/72

'02 CLK320 Cabriolet - wifey's mid-life crisis

2012 VW Jetta Sportwagon TDI...at least its a diesel

Non illegitemae carborundum.
Reply With Quote
Reply

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
Demystifying Oil - General high-level info about oil haasman Tech Help 6 04-21-2004 02:28 AM
Power Steering Problem - Need Advice arnelrac Tech Help 3 02-10-2002 12:05 AM
How to check the oil level from the instrument panel on a W202 Richard_D Tech Help 0 08-06-2001 11:07 AM
A few oil change questions... (C280) David C Klasse Tech Help 11 07-29-2001 02:14 AM
Oil Change Frequency mrbroche Tech Help 34 05-31-2001 11:03 PM



All times are GMT -4. The time now is 05:14 AM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
Search Engine Optimization by vBSEO 3.6.0
Copyright 2024 Pelican Parts, LLC - Posts may be archived for display on the Peach Parts or Pelican Parts Website -    DMCA Registered Agent Contact Page