|
|
|
#1
|
|||
|
|||
Greetings
We have a 87' 420SEL and the auto transmission has started to shift very rough when shifting from 1st to second and less rough shifting from 2nd to 3rd. It feels the way a manual transmission feels if you "drop" the clutch. The rough shifting is more pronounced when you accelerate slow and not as bad when you give it a little gas. The filter and fluid were changed about 25 k ago. Fluid level is fine, driveshaft, u joints, and rear end are fine. What could be the problem here? Is it a repair, and adjustment, or do I need a new tranny? If I need a new tranny would I be ok to get a rebuilt? And what are the potential costs of all this? Thanks in advance for any help. Bob |
#2
|
|||
|
|||
Modulator pressure is adjustable. The 420 and 560s have the additional common fault of the vacuum line to the modulator falling off the vacuum port. The port is hard to see but the line can be seen with the air filter off looking down the backside of the intake manifold. The large vacuum line going to the brake booster starts in this area. There is a banjo fitting and the small port is in that area. Look for the white plastic line passing under the crossover exhaust pipe. That is the line to the modulator. Be sure it is plugged in.
BTW the complete symptom package is a rough idle (vacuum leak) with harsh shifting.
__________________
Steve Brotherton Continental Imports Gainesville FL Bosch Master, ASE Master, L1 33 years MB technician |
#3
|
|||
|
|||
Steve, you nailed it!!
It was just as you suspected. The vacuum line was disconnected. Thanks!!!!!!!!!!!!
|
Bookmarks |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
'89 420SEL Transmission: Replace or Rebuild? | goldstone | Tech Help | 6 | 05-10-2005 01:43 PM |
420SEL Transmission Shift Points? | braverichard | Tech Help | 4 | 11-21-2004 08:44 PM |
Transmission Woes in Connecticut | fatcat | Diesel Discussion | 25 | 10-12-2003 07:48 AM |
99 S320 Transmission noise | BENZ TEK | Tech Help | 0 | 06-10-2003 10:32 PM |
Transmission Dip Stick - '86' 420SEL | maustin | Tech Help | 4 | 07-01-2001 08:54 PM |