|
|
|
#1
|
|||
|
|||
1994 E320 Aux fans
Can someone tell me where the sensor is that turns these fans on? They will run even when the car is cold. I am assuming it is a sensor that is bad!! Any help?
|
#2
|
|||
|
|||
There are two sensors..which speed are they staying ON ????
__________________
A Dalton |
#3
|
|||
|
|||
Quote:
High speed all the time. |
#4
|
|||
|
|||
The engine temp sensor has probably got a bad connection. Could be bad but the problem is often just the connection, wiggle it, unplug and replug it.
__________________
Steve Brotherton Continental Imports Gainesville FL Bosch Master, ASE Master, L1 33 years MB technician |
#5
|
|||
|
|||
As SB states, a a poor connection at that sensor will default the high fan to RUN.....
That sensor on that chassis it the blue, 2 wire one at the thermostat housing. You can also test the circuit by unplugging that connector and bridging the 2 wires with a 1K ohm resistor...that will put the fan off if the circuit is OK..if not, then the suspect is a sticking high fan relay..that is under the panel [ 6 screws] behind the fuse box..the Green relay..
__________________
A Dalton |
#6
|
|||
|
|||
OK I bridged the two wires @ 1k ohm resistance and the fans turned off. I checked the sending unit that the wires connect to and found when the sending unit is cold the circut is open when it's hot the same. Could this be a bad sending unit? I checked the sending unit with the wires off.
|
#7
|
|||
|
|||
Bad/Open sensor... The sensor is never open as it is a thermistor, so it always has a R value, temp dependent. If the ACC sees an open sensor, it defaults to full fan for engine overheat safety protection... [ your current condition]
http://catalog.worldpac.com/mercedesshop/sophio/wizard.jsp?partner=mercedesshop&clientid=catalog.mercedesshop&baseurl=http://catalog.peachparts.com/&cookieid=2AO123CS42D20NK27E&year=1994&make=MB&model=E-320-001&category=R&part=A%2FC+ACC+Temp+Sensor
__________________
A Dalton Last edited by Arthur Dalton; 05-05-2008 at 03:14 PM. |
#8
|
|||
|
|||
Thank You, Thank You, Thank You, I found a broken wire just inside the wiring harness. Works like a champ. Next on the fix it list. Any suggestions why my outdoor temperature gauge doesn't work. One day I looked at it and the numbers were gone.
|
#9
|
|||
|
|||
That chassis is infamous for bad engine wire harness..keep an eye on it..they fall apart.
__________________
A Dalton |
Bookmarks |
|
|