I have an 85' 300 diesel, non-turbo. It has 204,745mi on it as of today. I change my oil (have always used Mobil 1 full synthetic)every 3000mi with filter, and air filter every 6000. The fuel filters are <1000mi old.

My question is: Lately the engine will begin to lope (idle roughly) after extended driving (over 10mi) when the engine is at full operating temperature. Please note that idle speed does not affect the problem, as in this car there is a knob on the dash that controls idle speed. This problem is troublesome as it causes the car to shake while idling in gear. So far it has never stalled. What would cause this problem? I am confused because there is no problem when the engine is cool regardless of engine speed.

Could it be the injectors, the fuel pump, the fuel pump start-of-delivery adjustment, or transmission related? Also, I thought it could be something to do with the timing chain, as it could expand as the engine warms up. Please let me know if any of these could be the cause, or if I neglected some possibility.

TIA
Dr. Adam T. L. Delecki

How about the motor mounts? Have they been replaced recently?

__________________
2001 Dodge Ram 2500 Cummins Turbo Diesel - 4x4, auto, 3.54 gears, long bed
-------------------------------------
'92 300D 2.5 Turbodiesel - sold
'83 300D Turbodiesel - 4 speed manual/2.88 diff - sold
'87 300D Turbodiesel - sold
'82 300D Turbodiesel - sold

Sounds like the rack dampener needs adjustment. It is located on the back of the injection pump. Warm up the engine and then loosen the lock nut and screw in the adjusting screw until the shacking stops. You may need a new one if this does not help.

__________________
Mark
82 300SD 110k
91 Caprice SS
92 Jetta TD
97 Cadillac Concours(300hp)
84 Celebrity 4.3L diesel

If the rack dampener does not correct this, it is time to do a warm compression check.


Good luck,

When you say a "new one", do you mean a new fuel pump? Also, I had the compression checked at the dealership (Carson Pettit; Devon, PA) less than a year ago and they reported that the compression is so good that it is almost "new". What does the rack dampener control?

TIA
Dr. Adam T. L. Delecki

You may need a new rack dampener. They run $20-30.
It takes the oscillation out of the fuel rack at idle. A diesel tends to 'hunt' for its idle speed which causes the engine to shake. The dampener has a spring loaded pin which takes the back and forth motion out of the fuel rack.

__________________
Mark
82 300SD 110k
91 Caprice SS
92 Jetta TD
97 Cadillac Concours(300hp)
84 Celebrity 4.3L diesel