PeachParts Mercedes-Benz Forum

PeachParts Mercedes-Benz Forum (http://www.peachparts.com/shopforum/)
-   Tech Help (http://www.peachparts.com/shopforum/tech-help/)
-   -   1989 300SEL not passing updated California emissions test (http://www.peachparts.com/shopforum/tech-help/59483-1989-300sel-not-passing-updated-california-emissions-test.html)

stephenson 03-13-2003 01:26 AM

1989 300SEL not passing updated California emissions test
 
My friend's 1989 300SEL, with about 160K on it (no oil burning, runs very, very well and is maintained quite well by a very interested husband and a competent independent shop) recently failed the California emissions test ... I don't know which category of emissions was the problem ... we did not connect well on the technical issue.

She took the car to three places - two indies and one dealer and got the same response ... "your car won't pass the new rules in California." Her numbers are actually lower than three years ago, but new rules put her below the line. There is nothing wrong with her numbers .... just rules change ...?

Can someone enlighten me what this means? Have they toughened up rules without grandfathering? She was told at all three places that the car likely has little value in California because of this ...

If this is true, what can she do to modify her engine (change timing, use additives, change thermostat to hotter, etc) that might get her back above the line?

Should I buy it and take it back to Virginia with me? It is nearly flawless with new transmission, tires, chromed wheels, etc.

Thanks for any advice!

sbourg 03-13-2003 10:25 AM

The lack of technical information makes it impossible to answer. You need to ask the testers what concerns them. How do you know the car tests lower now than it did three years ago? If it failed emissions, this means it doesn't. The same parameters are measured as specified when the vehicle was manufactured. Your friend would have been given a printout with all the information.

As far as I am aware, the only thing that has changed with the new testing procedures is the requirements that a dynamometer setup be incorporated, and that a 'test only' facility be used on vehicles above a certain age (if so ordained by the DMV). Since results are transmitted directly to the DMV, cheating is much harder too.

Finally, if the issue is an incompatibility between the CIS engine management and testing procedures, mediation needs to be done with an appeal to CARB, and there would be a lot of interest in this case.

Steve

sixto 03-13-2003 03:25 PM

From what little I've read, they changed the testing procedure, not the emissions limits. Now there's a dyno test, not just a 2500rpm idle test.

Why would that change anything? Cars like that have been tested using Smog Check II in LA and Sac county for years?

Sixto
91 300SE
87 300SDL
83 300SD

sergio 03-13-2003 07:46 PM

Stephenson,
I don't want to advertise here but I think that this is a good cause.
If its combustible is gasoline, try to fit an Ecotek device in the engine. If your friend's problem is lowering emissions, this valve could do miracles. I tested one by myself.

Sergio


All times are GMT -4. The time now is 05:13 AM.

Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
Search Engine Optimization by vBSEO 3.6.0
Copyright 2024 Pelican Parts, LLC - Posts may be archived for display on the Peach Parts or Pelican Parts Website