|
|
|
#1
|
|||
|
|||
Rear door STUCK OPEN - will not close at all.
Well I opened the rear passenger side door and it will not shut at all. Something in the catch strap assembly went wrong and the door stays fully opened.
If I push on it, it feels like I am going to damage the door if I force it closed. I know the problem in the the catch strap but any idead or insight on fixing this? Also what are some tips on removing the door panel? This is a very clean 123 and I dont want to damage it.
__________________
1985 300D : the clean one 180k miles - Now passed onto my parents. 2000 E39 M5 2002 e46 330xit 1991 mustang notch (project) 1970 chevelle (project) |
#2
|
||||
|
||||
Do not force the door closed. You can damage it.
Your check strap failed at the worst time. The check strap has to be replaced, or you can use the door w/no check strp, but a good wind can open the door too far and cause damage as well. Use wide bladed putty knife to pop the door panel retainers.
__________________
RRGrassi 70's Southern Pacific #5608 Fairmont A-4 MOW car 13 VW JSW 2.0 TDI 193K, Tuned with DPF and EGR Delete. 91 W124 300D Turbo replaced, Pressure W/G actuator installed. 210K 90 Dodge D250 5.9 Cummins/5 speed. 400K |
#3
|
||||
|
||||
When mine went out (they always fail open ) I cut the end of the strap off until I could order a new one. I also disconnected the vacuum lock system for those few days to leave that door permanent locked so avoid a potential over-swing.
__________________
Adam Lumsden (83) 300D Vice-President of the MBCA International Stars Section |
#4
|
|||
|
|||
Once you get the door panel off. the check strap is inside the door with 3
little bolts holding it on. first remove the pin where the strap is attached to the door post. there is also a "C" clip holding it on the bottom. when these things have acted up, I have tried to grease them to no avail. they still wouldn`t work. just replace them, will eliminate a lot of frustration. Charlie
__________________
there were three HP ratings on the OM616... 1) Not much power 2) Even less power 3) Not nearly enough power!! 240D w/auto Anyone that thinks a 240D is slow drives too fast. 80 240D Naturally Exasperated, 4-Spd 388k DD 150mph spedo 3:58 Diff We are advised to NOT judge ALL Muslims by the actions of a few lunatics, but we are encouraged to judge ALL gun owners by the actions of a few lunatics. Funny how that works |
Bookmarks |
|
|