|
|
|
#1
|
|||
|
|||
wont start with key switch?
I have a 240d just got and it start only when jumping across soneloid, key switch doesnt wrk. I s there a fuseable link or relay bad,, I think it is some kind of wiring problem , but not sure where to start...Got any ideas?? Thanks
|
#2
|
|||
|
|||
I would look at the ignition switch, NSS, grounds and connections for starters. Also bench test the relay for the starter.
__________________
1986 300SDL, 211K,Dealership serviced its whole life 1991 190E 2.6(120k) 1983 300D(300k) 1977 300D(211k) |
#3
|
||||
|
||||
sounds like its time to break out the multimeter and start testing. The NSS is definitely a likely culprit - and when you're down there, check the shift linkage bushings to make sure they're not at fault either. The ignition switch is kind of a PITA to get at so I would leave that until last. Its all a matter of testing continuity and working your way up river.
__________________
TC Current stable: - 2004 Mazda RALLYWANKEL - 2007 Saturn sky redline - 2004 Explorer...under surgery. Past: 135i, GTI, 300E, 300SD, 300SD, Stealth |
#4
|
||||
|
||||
I'll agree with the Neutral Start Switch suggestion.
__________________
83 SD 84 CD |
#5
|
||||
|
||||
It would be nice if you updated your sig to include the cars data. Manual tran have no NSS. But I too agree this is the most common culprit. Unless some idiot forgot to tighten the solenoid wire screw all the way. *whistles*
__________________
http://superturbodiesel.com/images/sig.04.10.jpg 1995 E420 Schwarz 1995 E300 Weiss #1987 300D Sturmmachine #1991 300D Nearly Perfect #1994 E320 Cabriolet #1995 E320 Touring #1985 300D Sedan OBK #42 |
#6
|
|||
|
|||
Thanks for the reply
It is an auto trans and neutral switch should be down underneath at linkage for the trans correct.. Also where is a good place to get a wrk shop manual..thanks
|
#7
|
||||
|
||||
http://www.peachparts.com/shopforum/showthread.php?p=646647
Here you go - this is from the DIY section (under "resources" on the top navigation). Found it as I was looking up my own issues
__________________
TC Current stable: - 2004 Mazda RALLYWANKEL - 2007 Saturn sky redline - 2004 Explorer...under surgery. Past: 135i, GTI, 300E, 300SD, 300SD, Stealth |
#8
|
||||
|
||||
If 240Ds were all made before 1985 you can get the Factory Service Manual CD set directly from Mercedes. $19.99+$7 shipping.
http://www.classictechlit.mbusa.com/MB/category.asp?Page=1&catalog_name=Retail&category_name=1009
__________________
84 300D, 82 Volvo 244Gl Diesel |
Bookmarks |
Thread Tools | |
Display Modes | |
|
|