PeachParts Mercedes-Benz Forum

PeachParts Mercedes-Benz Forum (http://www.peachparts.com/shopforum/index.php)
-   Tech Help (http://www.peachparts.com/shopforum/forumdisplay.php?f=1)
-   -   Aux fan cycles on/off (http://www.peachparts.com/shopforum/showthread.php?t=97314)

OKC190 06-19-2004 10:52 PM

Aux fan cycles on/off
 
My 1991 190E 2.3 aux fan has recently started cycling on and off pretty frequently, like every couple of seconds. It doesn't always do it, but will once the temperature has gotten to aobut 80C. It was operating fine, coming on at 100 C like it should, but then started operating erratically. It does it without the A/C operating, so I don't think it's the high pressure switch. I measured the resistance of the coolant temp sensor, and it was about correct. Any suggestions as to the cuplprit? It seems as though it should be the coolant temp sensor, but it seems to check out. Thanks for your suggestions!

Arthur Dalton 06-20-2004 10:40 AM

First..
Check the CT sensor [ high speed fan] connection...clean the
plug/connector.
If the ECU sees an open connection there , it defaults into high fan circuit.
If connection is good, You could have an intermittent bad sensor...

OKC190 06-22-2004 10:57 PM

A little more information on the aux fan cycling. I pulled the connector on the coolant sensor, and to my surprise, the fan continued cycling on and off. I'm sure I have the right 4-pin, but without being connected, I would have expected to have the fan not run at all, or to run all the time. I'm pretty confident that the sensor is fine. It has all the correct resistance values over a range of temperatures. I don't understand where the ecu is getting the signal to turn the fan on and off. I can hear the relay pulling in and out. Any other ideas?
Thanks!

Joseph_190E 08-13-2004 05:20 PM

Did you ever figure this out?

pmizell 08-14-2004 12:49 AM

The ACC temp sensor that you should be looking for is 2 pole blue not the 4 pole black at the rear of the head.


All times are GMT -4. The time now is 12:11 PM.

Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2021, vBulletin Solutions, Inc.
Search Engine Optimization by vBSEO 3.6.0
Copyright 2018 Pelican Parts, LLC - Posts may be archived for display on the Peach Parts or Pelican Parts Website