|
|
|
#1
|
||||
|
||||
Any AC repairs easier with dash off?
Hopefully this is the last of my 'dash is off what now' series of questions...
I know the evaporator, but other than that? Im hoping mine is ok. My AC is not working for yet unknown reasons. Its not imperative that I fix right now, but if its easier :-) Thanks again, dd
__________________
------------------------------- '85 300D, 'Lance',250k, ... winter beater (100k on franken-Frybrid 3 Valve Kit) '82 300D, 'Tex', 228k body / 170k engine ... summer car '83 300TD Cali Wagon 210k, wife's car |
#2
|
|||
|
|||
Maybe replace the vacuum pod that controls air to the center vents?
|
#3
|
||||
|
||||
While the dash is out I would replace all the vacuum elements to the Ac system. They can be done with the dash in, but a difficult job.
http://www.peachparts.com/Wikka/W123HVACVacuumActuators If money is a factor Just replace the center vent element, it is the most difficult. All others can be done with the dash installed with just a bit of difficulty, but no where near the amount of cuts and swearing as with the center vent element. Evaporator drain tube. Check all grounds, clean and reattach then seal. Temp sensor foam tube but do it with a hard plastic tube, it will last forever. Dave
__________________
1970 220D, owned 1980-1990 1980 240D, owned 1990-1992 1982 300TD, owned 1992-1993 1986 300SDL, owned 1993-2004 1999 E300, owned 1999-2003 1982 300TD, 213,880mi, owned since Nov 18, 1991- Aug 4, 2010 SOLD 1988 560SL, 100,000mi, owned since 1995 1965 Mustang Fastback Mileage Unknown(My sons) 1983 240D, 176,000mi (My daughers) owned since 2004 2007 Honda Accord EX-L I4 auto, the new daily driver 1985 300D 264,000mi Son's new daily driver.(sold) 2008 Hyundai Tiberon. Daughters new car |
#4
|
||||
|
||||
Thank you dave.
What do I seal the ground with? Vaseline?
__________________
------------------------------- '85 300D, 'Lance',250k, ... winter beater (100k on franken-Frybrid 3 Valve Kit) '82 300D, 'Tex', 228k body / 170k engine ... summer car '83 300TD Cali Wagon 210k, wife's car |
#5
|
||||
|
||||
Dielectric grease, vaseline, paint, just about anything that will keep water and air out of the wire connections.
Dave
__________________
1970 220D, owned 1980-1990 1980 240D, owned 1990-1992 1982 300TD, owned 1992-1993 1986 300SDL, owned 1993-2004 1999 E300, owned 1999-2003 1982 300TD, 213,880mi, owned since Nov 18, 1991- Aug 4, 2010 SOLD 1988 560SL, 100,000mi, owned since 1995 1965 Mustang Fastback Mileage Unknown(My sons) 1983 240D, 176,000mi (My daughers) owned since 2004 2007 Honda Accord EX-L I4 auto, the new daily driver 1985 300D 264,000mi Son's new daily driver.(sold) 2008 Hyundai Tiberon. Daughters new car |
Bookmarks |
|
|