Parts Catalog Accessories Catalog How To Articles Tech Forums
Call Pelican Parts at 888-280-7799
Shopping Cart Cart | Project List | Order Status | Help



Go Back   PeachParts Mercedes-Benz Forum > Mercedes-Benz Tech Information and Support > Tech Help

Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 03-31-2004, 03:41 PM
Registered User
 
Join Date: Apr 2002
Location: Melbourne, Australia
Posts: 280
Question battery recharging

I have a 1997 C180 Euro version and I need to recharge my battery which is in the boot at the back next to the spare tyre. Can I just plug in the 2 terminals from the recharger or should I disconnect the 2 wires or just the ground wire only? Do I have to take the whole battery out of the car? Do I have to open the top plugs to allow gas to escape if they can be opened? How long should I leave the power on safely? This battery is almost flat due to the car being on the dealer's floor for the last 2 weeks. I can only use the car on weekends and this is not enough use to recharge the battery fully. Do I have to reset anything besides the radio after this? Where is the radio code and how do I reset it? Thanks guys.


Last edited by Hocky; 03-31-2004 at 03:48 PM.
Reply With Quote
  #2  
Old 03-31-2004, 07:23 PM
Registered User
 
Join Date: Mar 2004
Location: Victoria, Australia
Posts: 6
Haven't had to do this on my C180 yet, but I'd disconnect both connections before putting on the charger's crocodile clips.

Whether or not you open the breather plugs I guess depends on the power of the charger you're using. If it's a trickle charger, putting out no more power than the usual charge to the battery from the alternator, I'd leave them closed.

Unless you can find the PIN number for the radio somewhere, the owner's manual says you'll have to go to a dealer. Fortunately, the previous owner of my car had written "R/C ......" on the last page of the service booklet in the glovebox. It's a 6 digit number, so look for something like that.

According to the manual, if the battery's been disconnected, the engine management has to "learn" everthing again, so you have to take the car for a reasonable drive, exposing it to various speeds and conditions.

Cheers...
Reply With Quote
  #3  
Old 03-31-2004, 10:56 PM
Registered User
 
Join Date: Feb 2004
Location: Franklin, MA
Posts: 47
No reason to disconnect anything

There is no reason to disconnect anything. In fact, you can even charge the battery from the cigarette lighter if you wanted to and had a suitable plug. Just be careful you get the polarity right. If you disconnect the battery from the car, you will lose your radio code, clock, reset the computer, etc. and the battery will charge a bit faster due to no load on it. If you don't disconnect it these electrical systems will take power from the battery and charger, and you will charge slower.

A car battery is in the neighborhood of 60amp/hrs or so. Charging it at 1/10th capacity is a safe bet. You can use any 12 volt power supply. Just check the amp output of the power supply. Divide the total battery amps but the output of your charger and that should give you an idea of how long you need to charge the battery to fill it up if it was totally empty. For example, if your battery is 60 amp hrs, and you have a 2 amp charger, it would take 30 hours to charge your battery. Of course there are other variables like the current draw of the on-board systems, and the amount of charge left in your battery.

If I was you, I would charge it overnight with something that is not too high power, so , 5amp hrs or less so there is no chance of overcharge. Then, in the morning, if the car starts on its own just drive away and don't worry about it any more. It may take several trips, but eventually the battery will charge fully by itself from the on-board alternator. All you need to do is charge it enough to start the car, and then you are good to go. Do not disconnect the battery to charge it as that only adds more work for you resetting radio code, stations, clock, etc. Just charge it connected and let it take a couple of hours longer due to it being connected -- much easier that way.

Just an an example for you, last winter I had issues with my car where it wouldn't start. I cranked and cranked it until I killed the battery and then I couldnt crank it any more. I put the charger on overnight (it was a 1 amp charger or a trickle charge) while I was working on the car (drying wires and such as it was wet and not starting because of that I thought). Anyway, next day I was able to start it, but the battery was still weak. I drove it around to work and back, and, it took about 1 month of driving to work and back before the green eye on the battery was green again, indicating a full charge. So it may take a while, but as long as it starts and you are driving the car, eventually the battery will get topped off.

Hope this helps!

-=>Raja.

__________________
1983 MB 190E, bought from Germany and shipped to the US in 1986.
Reply With Quote
Reply

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On
Trackbacks are On
Pingbacks are On
Refbacks are On




All times are GMT -4. The time now is 11:41 AM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
Search Engine Optimization by vBSEO 3.6.0
Copyright 2024 Pelican Parts, LLC - Posts may be archived for display on the Peach Parts or Pelican Parts Website -    DMCA Registered Agent Contact Page