|
|
|
#1
|
||||
|
||||
I know this sounds crazy but...
Can you tell the general health of an injection pump by listening to it?
I tried this a week ago, some of them sounded authoritive like deep and hollow drums, while other where far more vague/soft/anemic in sound. Is there any bearing in this?
__________________
1998 Ford Escort ZX2 5 speed - 279,000 miles My Daily 1992 Mercedes 300D 2.5 202,000 - Pure junk 2000 Mercedes E320 Black - 136,000 miles - Needs repair Don't forget to grease the screw and threads on the spring compressor. |
#2
|
||||
|
||||
Where did u do this??
__________________
|
#3
|
||||
|
||||
You can tell if the delivery valve is seating positively or not. You should hear a "click" every time the cylinder fires if it is. If you hear a squeak or no click, you know the DV isn't seating. Use a good mechanic's stethoscope.
There's also a couple of ball bearings on the camshaft in the IP. Listening is one of the ways I determined my original IP was toast. You could hear it knocking in the governor section. Upon teardown, the rear ball bearing had failed.
__________________
Current stable: 1995 E320 149K (Nancy) 1983 500SL 120K (SLoL) Black Sheep: 1985 524TD 167K (TotalDumpster™) Gone but not forgotten: 1986 300SDL (RIP) 1991 350SD 1991 560SEL 1990 560SEL 1986 500SEL Euro (Rusted to nothing at 47K!) |
#4
|
||||
|
||||
Quote:
Also what should a healthy waterpump sound like?
__________________
1998 Ford Escort ZX2 5 speed - 279,000 miles My Daily 1992 Mercedes 300D 2.5 202,000 - Pure junk 2000 Mercedes E320 Black - 136,000 miles - Needs repair Don't forget to grease the screw and threads on the spring compressor. |
#5
|
|||
|
|||
I don't know how you could judge leakage past each piston in an injection pump, other than removing it and testing it on a Bosch machine. One guy here was investigating measuring the pressure pulses on-car via sensors on each injector tube, but that is a science project (piezo sensors or strain gages w/ high-speed data acquisition).
One might rig a tubing system w/ injectors to test it on-engine, collecting each spray in a graduated cylinder, as one does in gas engine injector testing. That would at least tell if the circuits are balanced in volume. One needs injectors on the tubes to build up back-pressure. Balance is critical in gas engines since the fuel control has a single O2 sensor to adjust multiple injectors (or at least 1 per engine bank), so assumes all are balanced to control the proper O/F in each cylinder. A diesel fires over a wide O/F range, which is why it runs WOT (i.e. no throttle plate to control air flow), so I expect balancing the cylinders would mainly affect how smooth the engine runs. Of course too much leakage also limits max fuel flow and thus power.
__________________
1984 & 1985 CA 300D's 1964 & 65 Mopar's - Valiant, Dart, Newport 1996 & 2002 Chrysler minivans |
#6
|
||||
|
||||
Hey if it runs good and delivers fuel, don't go poking where you don't need to. Enjoy it and drive it. If it ain't broke don't fix it.
__________________
Only diesels in this driveway. 2005 E320 CDI 243k Black/Black 2008 Chevy 3500HD Duramax 340k 2004 Chevy 2500HD Duramax 220k |
#7
|
||||
|
||||
Quote:
Even at full operating temp it sometimes has the hickups. What I do know for a FACT is cylinders 2 and 6 are at fault, had a video covering this. Why are they performing horribly, no clue. Tried multiple times to do a leakdown test but failed because I don't know how to line everything up.
__________________
1998 Ford Escort ZX2 5 speed - 279,000 miles My Daily 1992 Mercedes 300D 2.5 202,000 - Pure junk 2000 Mercedes E320 Black - 136,000 miles - Needs repair Don't forget to grease the screw and threads on the spring compressor. |
#8
|
|||
|
|||
My rule of thumb on water pumps is replace by default if it's more than 10 years old. If you don't know how old it is, assume its original. Same for all of the coolant hoses, since its much easier to replace pump and hoses all at once. The parts are inexpensive, and a failure will leave you on the side of the road and/or cook your engine, so I err on the side of caution here.
__________________
1998 E300 turbodiesel America's Rights and Freedoms Are Not The Enemy! |
Bookmarks |
|
|