|
|
|
#1
|
||||
|
||||
Drilling through firewall??
Was thinking about installing a boost gauge in my 1995 S-350 diesel and would like to know the best way to route the hose. I am kinda leary of drilling a hole through the firewall as good as Mercedes has the interior sealed off. Don't want a lot of air or road noise coming through. Any ideas??
__________________
1995 S-350 370K + SOLD 1952 220B Cabriolet 39K kilometers + SOLD 1998 E300D 310K + 2012 E350 BlueTec 120K |
#2
|
|||
|
|||
If the hose is long enough you can try to pass it through the rubber gromet together with the electrical wires behind the glovebox, otherwise choose another factory installed wire or cable (such as the throttle) that goes through the firewall and see if you can squeeze the hose through the same hole. If you can not, then drill a small hole next to the one that the wire or cable you selected goes through. When you are done get some silicon and spread it around the hole that you drilled (after you pass the hose through, of course) so that you can seal out any water from entering the interior. Do not drill through the floor because it consists of two layers spaced about 3 inches apart.
|
#3
|
||||
|
||||
Good suggestion
I am very against drilling into firewalls unless as a last resort. Try looking through the glovebox or the drivers' panel as suggested.
__________________
... Kerry 126 tailed by a 203, 129 leading the pack. |
#4
|
|||
|
|||
An alarm installation company drilled through the firewall of my old 190E, right into the power brake booster! They didn't make any money on that job.
|
Bookmarks |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Alaska Gov. Pushes for Oil Drilling Near ANWR | mikemover | Off-Topic Discussion | 49 | 08-24-2004 08:15 PM |
interior drilling | bsf24 | Tech Help | 4 | 11-17-2003 11:56 AM |
Win2000 processes and EPC vs firewall | sixto | Off-Topic Discussion | 3 | 08-03-2003 08:56 PM |
Getting thru front firewall 95 E320 W124 Cab? | carrerascott | Car Audio and Multimedia | 11 | 03-01-2003 10:47 AM |
140 Firewall Access Points | oldsouth | Diesel Discussion | 1 | 04-04-2002 07:59 PM |