|
|
|
#1
|
|||
|
|||
rough idle at operating temp.
I would like to request some help with my 1989 560SEL. It has had a rough idle at after it is warmed up since I bought it at 122k. I had the valves, injectors, fuel distrubutor. intake gaskets plugs changed with no improvement. The fuel distributor has been replace as well. I am frustrated with taking to shops and dealers as I have spent easily 10k chasing this issue to no avail.
I would sure appreciate any help. I have a reasonable mechanical background and am not intimidated by working on the car myself. Also I should mention the smog pump is frozen, and removed at this time. I may replace it but I can't imagine this would be part of the problem. Any and help appreciated. Bill |
#2
|
|||
|
|||
Hi Bill - I have a 88 560sel. Had rough idle ( just slight shake - the odd miss) for two years. I finally found it!! Take the injector lines off the fuel distributor and VERY GENTLY remove the fine screens in the fuel distributor that filter dirt from going to each injector. What I used was a thin long screw with a very sharp point and turned it slightly to just grab the screen to be able to pull it out, being careful not to make a big hole in the screen. You could buy new screens - see if Phil has them here - for the price it might make it easier for you. If you see dirt on the screens - you have found the problem. I would clean mine and the car would idle smoothly for about 2 weeks and then start missing again. Problem??? Rusted fuel lines from the tank. The fuel filter is in BACK of the car so it cannot catch the rust as it comes off the inside of the lines. The last stop before injectors is the screen filters in the fuel distributor. When I took my lines out (pain in butt at back by fuel tank) -one broke in two from it's own weight. New lines = no more rough idle. At idle there was enough dirt on the screen to slow the fuel delivery causing the roughness--when you stepped on the gas it worked OK injector cleaners helped very little. Hope this helps you.
Maurice |
Bookmarks |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
rough or loping idle under strange conditions | odie | Diesel Discussion | 0 | 01-20-2005 02:04 PM |
Possible HUGE issue: MB dealers issuing potential problem spark plugs, rough idle | ericgr | Mercedes-Benz SL Discussion Forum | 1 | 09-24-2004 07:33 PM |
240D "nailing" & rough idle | TedG | Tech Help | 0 | 07-28-2004 12:44 PM |
M103 hard start, rough idle, hesitation SOLVED | tryan | Tech Help | 9 | 02-12-2003 05:00 PM |
Rough smooth intermittent idle | keithed | Tech Help | 7 | 12-07-2002 12:31 PM |