|
|
|
#1
|
|||
|
|||
E-Class A-Pillar Clacking / Rattling TSB
My car just began suffering from this affliction. A hardcore rattling is emanating from under the speaker area at the lower corner of A-pillar, but I have now confirmed that it is originating from the A-pillar / wheelhouse junction.
There was a TSB that referenced a missing tack weld on some cars in this area that turns into a rattling, clacking sound over time. Can anyone post a PDF of this TSB? I'd like to rectify the problem with factory documentation if possible. Thanks, Gregg
__________________
Gregg '92 500E (Sold) '07 E63 AMG (Sold) '10 S550 |
#2
|
|||
|
|||
OK I found the info on my WIS software.
It had a good illustration on where to check for the missing welds. Discovered the welds were in fact there. Noticed that flexing the front fender would reproduce the clacking creaking sound. Loosened up top fender mounts, lubed with Tri-Flow teflon lubricant, tightened hardware, and horrible clacking rattle is GONE. Resolution: if the corner of your dash near windshield sounds like a coffee can full of screws, check the fender/wheelhouse area under the hood before tearing the whole right side of the dash apart (like I did).
__________________
Gregg '92 500E (Sold) '07 E63 AMG (Sold) '10 S550 |
#3
|
|||
|
|||
I remember suffering from this on my 300E. Yes, it was front fender-related, passenger side. Loosening and then re-tightening the upper bolts fixed my problem as I recall.
__________________
08 W251 R350 97 W210 E320 91 W124 300E 86 W126 560SEL 85 W126 380SE Silver 85 W126 380SE Cranberry 79 W123 250 78 W123 280E 75 W114 280 |
#4
|
|||
|
|||
Just thought I'd bump this thread. I had a clacking/rattling coming from the a-pillar/speaker/windshield area. Very annoying. And it was starting to show up a little bit at idle too. Loosened and re-torqued the passenger fender bolts as per above, and its back to like riding in a bank vault again. Now onto the squeaks from the backseat area.
__________________
http://i193.photobucket.com/albums/z...-RESIZED-1.jpg 1991 300E - 212K and rising fast... |
Bookmarks |
|
|