Would disconnecting the EGR allow for my car to have a little more power? Also could i connect the pcv valve to a little filter, instead if to the intake manifold. I'm guess this is illegal, but...just wondering about the input

Thanks

Were you to post your car, you may get answers. Diesels have an EGR system, at least many years do. Yet no PVC filter, depending on car maybe.

__________________
83 SD

84 CD

1985 190D 2.2

thanks

I am unfamiliar with your car, and cannot help, I'm sure others are tho. If you put that info in your signature, you will not need to enter it every time. Or in the thread title.

__________________
83 SD

84 CD

Yes, killing the EGR will increase MPG and give you a bit more power.

I'd leave the CCV attached to the intake. Having it open to the air will make visible vapor and an oil odor around the car, even with a filter.

As Forced Induction said, killing the EGR will improve performance a little. It won't increase maximum power however because your accelerator linkage should have a switch that cuts it off when you floor it.

I also agree with him on leaving the ccv attached. A filter will do no good unless you have a way to drain the oil back into the engine. The small amount of oil ingested won't hurt any thing. Besides, since you paid for it, you might as well burn it as fuel rather than dump it into the atmosphere You want a vacuum in your crank case. It reduces the amount of air thrown around by the pistons inside the engine and can slightly increase the power at the top end.

__________________
green 85 300SD 200K miles "Das Schlepper Frog" With a OM603 TBO360 turbo ( To be intercooled someday )( Kalifornistani emissons )
white 79 300SD 200K'ish miles "Farfegnugen" (RIP - cracked crank)
desert storm primer 63 T-bird "The Undead" (long term hibernation)

http://ecomodder.com/forum/fe-graphs/sig692a.png

Even reading the threads about it, I'm still unclear exactly what to disconnect/plug with a BB in order to disconnect the EGR without actually physically removing valves and stuff.

I keep meaning to do it at some point, though.

__________________
1983 Mercedes-Benz 240D
Automatic, A/C, Power Sunroof, Power Right Side Mirror
231K Miles FOR SALE MAKE OFFER

Mine runs a bit smoother w/o the EGR on. It ** might** get 1-2 mpg more too.

Isnt rocket science, heck simply put a nail into the end of vacuum line to seal it. These guys use a BB so you can keep the line on the EGR to look right. uh, I actually used a bullet, since I reload, I gots plenty. In the line, not the EGR btw. Cant remember if it was a .224 or a .243. Hornady ballistic tip though, so I can grab the plastic end with pliers and pull it if need be.

Where is this located? (EGR line that can be plugged)

Here is a THREAD that shows some pics of the EGR and EGR removal and blocking

__________________
BENZ THERE DONE THAThttp://www.peachparts.com/shopforum/...c/progress.gif
15 VW Passat TDI
00 E420
98 E300 DT
97 E420 Donor Car - NEED PARTS? PM ME!
97 S500
97 E300D
86 Holden Jackaroo Turbo D
86 300SDL
(o\|/o)

Thanks for the info!

__________________
85 300SD
02 F350 Diesel 2WD
96 F250 Gas 4WD
02 Accent
06 KLR650
04 CRf450r
Mahindra 3525 Diesel

I pulled the hose off the EGR so I could plug it and guess what I found A BB someone beat me to it.

__________________
85 300SD
02 F350 Diesel 2WD
96 F250 Gas 4WD
02 Accent
06 KLR650
04 CRf450r
Mahindra 3525 Diesel