|
|
|
#1
|
||||
|
||||
Steam cleaning a W211 CDI engine bay, advise wanted.
I would ussually not think about doing this but, I just finished rebuilding the CP3 HP fuel pump due to a long time leak and the amount of diesel crud in the bottom end is unreal. Of course the scent is not something I want to deal with for much longer.
i sprayed some degreaser and cleaned to the best of my abilities, but I am thinking steam would be more efficient and safe than water to tackle this job. Has anyone gotten this done to any of their cars and is there anyone who knows who may be able to do it in beutiful New Jersey? Thanks in advance
__________________
W211 B-PILLAR TRIM PANEL REPLACEMENT My Continental Tire Experience By Land: 2005 E320 CDI (Unnamed as of yet) 2011 Toyota Tundra DC limited 4x4 "Big Red" 1965 euro import VW Beetle "Mojo" By Sea: 22' Grady White Seafarer "SeaSun Pass" Last edited by 65aircooled; 04-05-2014 at 10:34 PM. |
#2
|
|||
|
|||
Warm water (less than 140*) and a pressure washer should do the job. The temp. limit is to protect the pressure washer, not the engine. Unless you own one, I think you'll have a hard time finding a steam cleaner- they're fraught with all kinds of hazards.
__________________
'83 300D, 126K miles. |
#3
|
||||
|
||||
I think this topic has a lot of mixed opinions when this is discussed. There's a lot of horror stories about wiring harnesses, alternators etc. My opinion is if you're careful and cover the alternator with a plastic bag and avoid computers and don't aim your fire at those areas you should be ok. Just be careful. A steam cleaner to me is also is a bit more easing in my mind than a pressure washer anyway for some reason. Then whatever you miss with the cleaner, wax on wax off hand technique will go a long way.
|
#4
|
||||
|
||||
Is this the W211 that only has 59K or so miles on it?
|
#5
|
||||
|
||||
IDK which one you are thinking of, mine currently has 71500 miles.
Why, is there a set mileage in which parts should fail at?
__________________
W211 B-PILLAR TRIM PANEL REPLACEMENT My Continental Tire Experience By Land: 2005 E320 CDI (Unnamed as of yet) 2011 Toyota Tundra DC limited 4x4 "Big Red" 1965 euro import VW Beetle "Mojo" By Sea: 22' Grady White Seafarer "SeaSun Pass" |
#6
|
||||
|
||||
I think Skid Row Joe as asking since at such low mileage it really shouldn't be all that grungy yet.
Steam cleaning can be a real help, when it's done right and by a pro. The actual amount of water isn't is pretty low, and I think is safer to connectors, relays, and alternators than high pressure water. It's more expensive, but if you can find it, for sure the way to go.
__________________
1983 W123 300TD US spec Turbo engine, with Euro bumpers and manual climate control, and manual transmission. |
#7
|
||||
|
||||
Quote:
I think that parts fail regardless of mileage in all cars. Mine failed in the dead of a bad winter, and not looking to fork out $2300 for a new pump installed at the dealer, I de wait for better weather to fix it. So 70k plus miles of driving in NJ collecting road dust got mixed with a couple of thousand miles of diesel leaking from the CP3. I think that happens rather quickly, specially with a leak that is directly behind the fan and above the drive belt. I used a petroleum based degreaser yesterday to clean around the pump which was a bad judgement. The stench is even worse now. I am trying to find a shop that does steam cleaning but no luck so far.
__________________
W211 B-PILLAR TRIM PANEL REPLACEMENT My Continental Tire Experience By Land: 2005 E320 CDI (Unnamed as of yet) 2011 Toyota Tundra DC limited 4x4 "Big Red" 1965 euro import VW Beetle "Mojo" By Sea: 22' Grady White Seafarer "SeaSun Pass" |
#8
|
||||
|
||||
Quote:
__________________
Jim |
#9
|
||||
|
||||
Petroleum solvents and their residue / associated odors, will dissipate away over time by themselves. Re-emulsifying them through detergents and heated water is the best way to rid surfaces from them.
The belly pans that the W210 I owned, and the W211 I own now have both held petroleum solvents in the past. The residue is not always able to be immediately and completely negated with heated water and detergents from the plastic pans, but will disappear over time. |
#10
|
||||
|
||||
Quote:
Quote:
__________________
W211 B-PILLAR TRIM PANEL REPLACEMENT My Continental Tire Experience By Land: 2005 E320 CDI (Unnamed as of yet) 2011 Toyota Tundra DC limited 4x4 "Big Red" 1965 euro import VW Beetle "Mojo" By Sea: 22' Grady White Seafarer "SeaSun Pass" |
Bookmarks |
|
|