Parts Catalog Accessories Catalog How To Articles Tech Forums
Call Pelican Parts at 888-280-7799
Shopping Cart Cart | Project List | Order Status | Help




Go Back   PeachParts Mercedes ShopForum > Technical Information and Support > Tech Help

Closed Thread
 
LinkBack Thread Tools Display Modes
  #1  
Old 04-27-1999, 09:05 PM
Nick Jamal
Guest
 
Posts: n/a
Regarding an earlier post where I described the climate control working only intermittently - I have a few more details. It's finally warming up outside and I NEED air conditioning. After replacing practically the entire A/C system last year, I'm still having trouble. When idling, the compressor cycles regularly, and will do so forever. However, when the throttle is applied, the compressor cuts out - and stays off until the car is restarted. If the AC is activated while driving, it operates for a little while and then cuts out - again until the car is restarted. As I said, most components have been replaced, including the compressor, condenser, receiver/dryer, and the pushbutton control unit. When the MB dealer performed the socket box test, the suggestion was that the auxilary water pump (electric) was drawing too much - and interfering with feedback to the control unit. At their recommendation (and my expense), the pump was disconnected. This actually seemed to work for a while - but the problem is back, and I'm sweating. Any help/ advice would be greatly appreciated.
  #2  
Old 04-27-1999, 10:38 PM
Benzmac
Guest
 
Posts: n/a
I have had alot of experience with this subject and there are only a few things that can cause this.
1. If the poly-belt tensioner is the least bit loose and allows any slip, the compressor will cycle off until restart.
2. If the compressor relay is defective it can cause this. It isn't a pushbutton unit problem if it cycles OK.
3. The sensor in the rear of the compressor can go bad only above a certain RPM. It sould generate an AC sine wave at all RPMs going up in voltage as the RPM's increase.

------------------
Benzmac:
ASE CERTIFIED MASTER AUTO TECHNICIAN
LEAD TECHNICIAN FOR 14 BAY FACILITY
MERCEDES SPECIALIST 8 YRS
PARTNER IN MERCEDESSHOP.COM


  #3  
Old 04-27-1999, 10:47 PM
M.B.DOC
Guest
 
Posts: n/a
Mercedes designed the a/c compressor with a cut-out system to protect the multi-rib belt in case of compressor failure! The relay & related parts have costed Mercedes owners $$ & frustration. Sounds like your compressor relay doesn't THINK the the a/c compressor is going the correct speed, most likely a BAD A/C COMPRESSOR!! I understand that some "aftermarket" rebuilders of electronic componets (a/c relay) rebuild the relay & leave out the speed signal imputs.

------------------
MERCEDES BENZ MASTER GUILD TECHNICIAN
ASE MASTER TECHNICIAN
27 YEARS M.B. TECH
Closed Thread

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
FS 300e w124 PARTS ON EBAY!!!!!!! 6cndmbz Mercedes Used Parts For Sale & Wanted 4 09-20-2003 01:14 PM
300E misses with A/C on...Why??? mike690003 Tech Help 2 09-01-2003 05:45 PM
A/C Problem on a 124 1986 300E GP Tech Help 6 07-23-2003 11:06 PM
1987 300e A/c Push Button Problem TAYO Tech Help 5 07-22-2003 05:04 PM
is A/C cold for a 1987 300E? WANT '71 280SEL Tech Help 6 06-25-2003 12:18 AM



All times are GMT -4. The time now is 05:41 AM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2017, vBulletin Solutions, Inc.
Search Engine Optimization by vBSEO 3.6.0
Copyright 2011 Pelican Parts - Posts may be archived for display on the Peach Parts or Pelican Parts Website -    DMCA Registered Agent Contact Page